Volatile organic compounds emission

In addition to particulate emissions, volatile organic compounds (VOCs) may also be emitted when the slurry contains organic materials with low vapor pressures. The surfactants included in the slurry represent the origin of the VOCs. The vaporized organic materials condense in the tower exhaust air stream into droplets or particles. Paraffin alcohols and amides in the exhaust stream can result in highly visible plume that persists after the condensed water vapor plume has dissipated [4, 21]. Some of the VOCs identified in the organic emissions are hexane, methyl alcohol, 1,1,1-trichloroethane, perchloroethylene, benzene, and toluene [1-4]. 

Fugitive Emissions—Volatile organic compounds and other designated liquids or gases escaping from valves, piping, and equipment in minute amounts from each source but that cumulatively contribute to significant air pollution. 

Liquid nitrogen is used in cold traps to remove and recover solvents or volatile organic compounds from gas streams to reduce atmospheric emissions. Liquid nitrogen can be used to accelerate the cooldown time for process reactors (29). 

In the United States, the reportable quantity of 1-propanol for spills under CERCLA "Superfund" is 100 Ib/d (45.4 kg/d). However, no reportable quantity is assigned for transport (43). The substance is on the list for atmospheric standards, as defined iu 40 CER 60.489 (47). The iatent of these standards is to require all newly constmcted, modified, and reconstmcted manufacturiug units to use the best demonstrated system of continuous emission reduction for equipment leaks of volatile organic compounds (47). 1-Propanol is also on the right-to-know regulations of the states of Connecticut,... 

In 1990, a test using scrap tires (2x2 in. I DE) to generate steam for electricity was conducted at the Elexsys plant. The I DE replaced 20% of the plant s coal. Results showed that IDE is an environmentally sound fuel. Particulate emissions were reduced by the lower ash content of IDE, volatile organic compounds (VOC) were reduced because of more efficient burning of I DE compared to coal, and carbon dioxide emissions were reduced because I DE contains half the fixed carbon found in coal. Nitrogen oxide, chlorine emissions, and metals were also reduced, and ferrous metals and dioxins were nondetectable (7). 

Other. Numerous other supercritical fluid processes and techniques have been and are continuing to be developed. The novel spray appHcation UNICARB uses supercritical CO2 to replace volatile diluents in coating formulations, thereby reducing the volatile organic compound emissions by up to 80% (128). Rapid expansion of CO2 iu the spray can also improve the quaUty of coatings, thus performance benefits are obtained in a process developed for environmental advantages. 

In 1966, the Los Angeles Air Pollution Control Board designated trichloroethylene as a photochemically reactive solvent that decomposes in the lower atmosphere, contributing to air pollution. In 1970 all states were requited to submit pollution control plans to EPA to meet national air quaUty standards. These plans, known as State Implementation Plans (SIPS), controlled trichloroethylene as a volatile organic compound (VOC). They were designed to have each state achieve the National Ambient Air QuaUty Standard (NAAQS) for ozone. The regulations were estabUshed to control the emission of precursors for ozone, of which trichloroethylene is one. 

J. Berry, "Control of Volatile Organic Compound (V OC) Emissions from Painting Operations ia the United States," Polymers Paint Colour J. 181(4281), (Apr. 17,1991). 

Supercritical Atomization. Atomization can be obtained by mixing a supercritical fluid (SCF) with the material to be atomized. This process reduces volatile organic compound (VOC) emissions as the SCF acts as a solvent and replaces some of the hydrocarbon solvents in the material (see... 

Human-made sources cover a wide spectrum of chemical and physical activities and are the major contributors to urban air pollution. Air pollutants in the United States pour out from over 10 million vehicles, the refuse of over 250 million people, the generation of billions of kilowatts of electricity, and the production of innumerable products demanded by eveiyday living. Hundreds of millions of tons of air pollutants are generated annu ly in the United States alone. The five main classes of pollutants are particulates, sulfur dioxide, nitrogen oxides, volatile organic compounds, and carbon monoxide. Total emissions in the United States are summarized by source categoiy for the year 1993 in Table 25-10. 

Method 25 applies to the measurement of volatile organic compounds (VOC) as nonmethane organics (TGNMO), reported as carbon. Organic particulate matter will interfere with the analysis, and, therefore, in some cases, an in-stack particulate filter will be required. The method requires an emission sample to be withdrawn at a con-... 

Provide annual estimates of all point and fugitive emission sources (tons per year) of hazardous substances, volatile organic compounds (VOCs), heavy metals and fossil fuel products (for example, NOx and SOx) that are released to the environment. 

Within 6 months after enactment of the Qean Air Act Amendments of 1990, and at least every 3 years thereafter, the Administrator shall review and, if necessary, revise, the methods ( emission factors ) used for purposes of this Act to estimate the quantity of emissions of carbon monoxide, volatile organic compounds, and oxides of nitrogen from sources of such air pollutants (including area sources and mobile sources). In addition, the Administrator shall permit any person to demonstrate improved emissions estimating techniques, and following approval of such techniques, the Administrator shall authorise the use of such techniques. Any such technique may be approved only after appropriate public participation. Until the Administrator has completed the revision required by this section, nothing in this section shall be construed to affect the validity of emission factors established by the Administrator before the date of the enactment of the Clean Air Act Amendments of 1990. 

The UK Environment Agency deals with over 6000 oil pollution incidents each year. One estimate suggests tliat tlie cheiTtical industry contributes to 50% of all ah pollution witli proportions approximating to sulphur dioxide (36%), carbon dioxide (28%), nitrogen oxides (18%), carbon monoxide (14%) and black smoke (10%). Motor spirit refining is responsible for ca 26% of emissions of volatile organic compounds to the atmosphere. In 1996 there were over 20 000 reports of water pollution incidents with 155 successful prosecutions. 

EC Directive on the control of volatile organic compounds (VOC) emissions resulting from the storage... 

EC Directive on limitation of emissions of volatile organic compounds (VOCsJ due to the use of... 

Carlson, F.E., Phillips, E.K., Tenhaeff, S.C. and Detlefsen, W.D., Measuring and Controlling Volatile Organic Compound and Paniculate Emissions from Wood Processing Operations and Wood-Based Products. Forest Products Society, Madison WI, 1995, pp. 52-61. 

---