Recovery, classifiers

Flotation reagents are used in the froth flotation process to (/) enhance hydrophobicity, (2) control selectivity, (J) enhance recovery and grade, and (4) affect the velocity (kinetics) of the separation process. These chemicals are classified based on utili2ation collector, frother, auxiUary reagent, or based on reagent chemistry polar, nonpolar, and anionic, cationic, nonionic, and amphoteric. The active groups of the reagent molecules are typically carboxylates, xanthates, sulfates or sulfonates, and ammonium salts. 

Some North Dakota lignite ashes have also been observed to have above-average concentrations of uranium (21,22), lea ding to interest in processing the ash for uranium recovery. However, this ash may be classified as hazardous. 

Gas-phase separations may be classified as enrichment, sharp, or purification separation, depending on the purity, recovery, and magnitude of the pertinent separation. The classification system allows for a certain amount of synergy, as several separation methods may be combined in order to achieve the desired result. Certain separation methods ate favored for each category (26). 

Transportation and Disposal. Only highly alkaline forms of soluble sihcates are regulated by the U.S. Department of Transportation (DOT) as hazardous materials for transportation. When discarded, these ate classified as hazardous waste under the Resource Conservation and Recovery Act (RCRA). Typical members of this class are sodium sihcate solutions having sihca-to-alkah ratios of less than 1.6 and sodium sihcate powders with ratios of less than 1.0. In the recommended treatment and disposal method, the soluble sihcates are neutralized with aqueous acid (6 Af or equivalent), and the resulting sihca gel is disposed of according to local, state, and federal regulations. The neutral hquid, a salt solution, can be flushed iato sewer systems (86). 

In a general sense, however, the term heavy oil is often appHed to a petroleum that has a gravity <20° API. The term heavy oil has also been arbitrarily used to describe both the heavy oil that requires thermal stimulation for recovery from the reservoir and the bitumen in bituminous sand (also known as tar sand or oil sand) formations, from which the heavy bituminous material is recovered by a mining operation. Extra heavy oil is the subcategory of petroleum that occurs in the near-soHd state and is incapable of free flow under ambient conditions. The bitumen from tar sand deposits is often classified as an extra heavy oil. 

Another injectable anesthetic widely used in feline and primate practice is ketamine hydrochloride [1867-66-9]. Ketamine, a derivative of phencychdine, can be chemically classified as a cyclohexamine and pharmacologically as a dissociative agent. Analgesia is produced along with a state that resembles anesthesia but in humans has been associated with hallucinations and confusion. For these reasons, ketamine is often combined with a tranquilizer. The product is safe when used in accordance with label directions, but the recovery period may be as long as 12—24 h. 

Thermal treatment is used to destroy, break down, or aid in the desorption of contaminants in gases, vapors, Hquids, sludges, and soHds. There are a variety of thermal processes that destroy contaminants, most of which are classified as incineration. Incineration HteraHy means to become ash (from Medieval Latin, incinerare in or into ashes). With respect to the incineration of hazardous wastes regulated in the United States, however, there is a strict legal definition of what constitutes an incinerator. The Resource Conservation and Recovery Act (RCRA) definition of incinerator at 40 CFR 260.10 is... 

Cemented carbides play a cmcial role in the recovery of metallic ores and nonmetals by underground or open-pit mining practices, recovery of minerals such as coal (qv), potash, and trona, and drilling for oh and gas. The methods of excavation can be broadly classified into three types rotary... 

Trichloroethylene use has declined as a result of environmental concerns. However, trichloroethylene may replace some 1,1,1-trichloroethane appHcations. Perchloroethylene used in small businesses for dry cleaning will be regulated for emissions under the same guidelines as those that govern the large chemical producers. This will cause replacement of perchloroethylene for those appHcations where recovery is uneconomical. Methylene chloride has been classified as a suspected carcinogen and its use will decline in aerosol and paint stripping appHcations because of health concerns. 

Size Recovery and Yield Centiifuges have been apphed to classify polydispersed fine particles. The size distribution of the paiticles is quantified by the cumulative weight fraction F less than a given particle size d for both the feed and the centrate streams. It is measured by a particle size counter which operates based on piinciples such as sedimentation or optical scatteiing. 

Numerous applications where the recovery of power is important are being explored and exploited to an increasing degree. These are classified as turboexpander applications because of the importance of reliability and high efficiency. Turboexpanders meet these requirements and are available in the needed capacity ranges. A 5,000 hp (3,727 kW) compressor-loaded turboexpander is shown in Figure 2-10. 

RCRA was passed to manage nonhazardous and hazardous wastes and underground storage tanks, with an emphasis placed on the recovery of reusable materials as an alternative to their disposal. This act introduced the concept of the separate management of hazardous and nonhazardous wastes, and defined procedures to identify whether a waste is hazardous or nonhazardous. A waste exhibits the characteristic of toxicity, classified as a hazardous material, if the concentration of any of 39 selected analytes in the Toxicity Characteristic Leaching Procedure (TCLP) extract exceed regulatory action levels. 

Reaction of K3Co(CN) with PMMA. A 1.0 g sample of PMMA and 1.0g of the cobalt compound were combined in a standard vessel and pyrolyzed for 2 hrs at 375°C. The tube was removed from the oven and the contents of the tube were observed to be solid (PMMA is liquid at this temperature). The tube was reattached to the vacuum line via the break-seal and opened. Gases were determined by pressure-volume-temperature measurements on the vacuum line and identified by infrared spectroscopy. Recovered were 0.22g of methyl methacrylate and 0.11 g of CO and C02. The tube was then removed from the vacuum line and acetone was added. Filtration gave two fractions, 1.27g of acetone insoluble material and 0.30g of acetone soluble (some soluble material is always lost in the recovery process). The acetone insoluble fraction was then slurried with water, 0.11 g of material was insoluble in water. Infrared analysis of this insoluble material show both C-H and C-0 vibrations and are classified as char based upon infrared spectroscopy. Reactions were also performed at lower temperature, even at 260°C some char is evident in the insoluble fraction. 

The flotation of gold-bearing ores is classified according to ore type (i.e. gold ore, gold copper ore, gold antimony ores, etc.), because the flotation methods used for the recovery of gold from different ores is vastly different. 

Property other than buildings (18-year property) placed into service at the present time must use the modified accelerated cost recovery system (MACRS) in calculating depreciation. Property is classified as having 3, 5, 7, 10, 15, or 20 years life. Some examples are ... 

The cut point of 15 microns on the Alpine air classifier gave an fineicoarse split of 31.8 61.7 for field pea but the yield of protein fraction was much higher at 37.0% for fababean (Table II). Based on the protein contents of the fine fractions (Table I), the recoveries of protein in the fine fraction were 75.5% for field pea and 80.0%... 

Tail gas cleanup is required because a well-designed Claus plant with three catalytic stages and fresh catalyst will recover only 95-97% of its feed sulfur (8), which is not generally sufficient to meet current emission standards. In addition, feed impurities and catalyst aging will reduce overall recovery in some plants to about 92% just before catalyst changeout. Therefore, tail-gas cleanup is required. Tail-gas treating processes are generally classified as follows ... 

---