Trial operation

It is reported that Hitachi Zosen Corp. of Japan has begun trial operation of a commercial-scale device for the conversion of waste plastic to oil. Details of the device are provided. It is also reported that Mitsubishi Heavy Industries Ltd. (MHI) has installed a pilot plant for producing gas fuel from waste plastics. The MHI system is described. 

Following the procedure of Fig. 9.9 draw trial operating lines (see Fig. E9.6a) with a slope of (from Example 9.5), and for each evaluate the integral... 

Grants FDA greater authority over drug marketing, labeling, and direct-to-consumer advertising requires post-approval studies, establishes active surveillance systems, makes clinical trial operations and results more visible to the public. 

The trial operation shows that the design objectives for the VCISR have been essentially realized and the disadvantages that the SCISR has are overcome, giving a wider area of application of the flow configuration of the circulative impinging streams. 

The facility has been put into trial operation at laboratory. 

During two years of trial operation, the pilot plant demonstrated its suitability. Although the process can be considered proven, it is at present neither used by BASF, nor elsewhere in Germany, because the quantities of plastic waste and dump fee needed for the plant to be economically viable are not available in Germany (Figure 1.1). 

EVALUATION OF THE RESULTS FROM THE CO-COMBUSTION TRIALS OPERATING CONDITIONS OF THE BOILER... 

The above modifications were realized after detailed investigations into basic process conditions with short and long term trial operations. The typical operating condition and product yields are shown in Table 1. The credits of the modifications in 105 ton/hr feed case are summarized as follows ... 

Calculate the mobilized strength index, which is the ratio of the APSD to the trial operational unconfined strength. 

The result of the various investigations made for the Government was the recommendation that the War Department take over the process of the General Chemical Company and erect a pilot plant to test the process. Accordingly, U. S. Nitrate Plant No. i was erected at Sheffield, Ala. This plant of a capacity of 30 tons of ammonia, including the 7.5 ton unit which was to have been erected at Shadyside, was never completed. Only one unit of 7.5 tons of ammonia per day capacity was ready for trial operation prior to the signing of the armistice. Continuous operation of this unit was never realized, and duly a small amount of ammonia was produced. 

Integrated drug and device Single/ Clinically continuous trialed operation Breath- activated Delivers multiple doses before reloading is needed... 

A full-scale prototype of the gas circulator has been fabricated for testing at ST-1383 facility. Startup and trial operation of the facility under partial loads have been performed. The further testing has been delayed. 

About two events turned out to be caused by a critical organizational or management problem such as a violation of the prescribed shutdown time of a system or not informing the operating team of an important system operation setpoint which has been found during a trial operation. 

One approach to consider is a trial operation of the system, before the validation and the documentation of the system are finished, to find the working practices that will be used after the system becomes... 

Consent to move to each new system configuration state is sought by an apphcation to consent to operate or consent to trial operations , supported by an Engineering Safety and Assurance Case (ESAC), which sets out the justification for the assurance of the system, as it is at that... 

Usually, testing is the first life cycle stage that calls for a safety argument to be produced in support of carrying the testing or a trial operation. Production of such a Safety Justification is the first step towards the production of the safety case. Most often, the process for the... 

The HTR-PM plant is designed for a construction period of 48 months including site preparation, construction, commissioning and trial operation. The specific construction cost for HTR-PM is projected not to exceed 1500 US /kWe, and the generation cost is targeted to be about 4.5 cents/kW-h. The specific O M costs and fuel costs are estimated at 0.76 cents/ kW-h and 1.09 cents/ kW-h respectively. 

Tubular SOFC design is also attractive for residential units because of its reliable and stable performance over long periods. Kyocera (Japan) has developed anode-supported flat tubular cells, and these cells are being utilized by several organizations in Japan (Osaka Gas, Tokyo Gas, etc.) to fabricate and test SOFC-based residential CHP systems. The first trial operation of such a 1 kW unit in a residential house was conducted in 2005-2006 for a period of 2000 h the average electric efficiency and hot water heat recovery efficiency were 44.1 % (LHV) and 34 % (LHV), respectively. Over 75 such units, illustrated in Fig. 8, are now installed and operating in homes throughout Japan, and are expected to be commercialized in the next two years. 

---