Friedel synthesis

Benzilic acid rearrangement Benzoin reaction (condensation) Blanc chloromethylation reaction Bouveault-Blanc reduction Bucherer hydantoin synthesis Bucherer reaction Cannizzaro reaction Claisen aldoi condensation Claisen condensation Claisen-Schmidt reaction. Clemmensen reduction Darzens glycidic ester condensation Diazoamino-aminoazo rearrangement Dieckmann reaction Diels-Alder reaction Doebner reaction Erlenmeyer azlactone synthesis Fischer indole synthesis Fischer-Speior esterification Friedel-Crafts reaction... 

Synthesis hote that there is only one activated site for the Friedel-Crafts reaction - o and p to the two methyl groups but not between them for steric reasons ... 

Synthesis This route has been carried out successfully (Rec. Trav. Chem., 1958, 77, 854). Note that no AICI3 is needed for Friedel-Crafts alkylation with easily formed t-alkyl compounds. 

Cydopentane reagents used in synthesis are usually derived from cyclopentanone (R.A. Ellison, 1973). Classically they are made by base-catalyzed intramolecular aldol or ester condensations (see also p. 55). An important example is 2-methylcydopentane-l,3-dione. It is synthesized by intramolecular acylation of diethyl propionylsucdnate dianion followed by saponification and decarboxylation. This cyclization only worked with potassium t-butoxide in boiling xylene (R. Bucourt, 1965). Faster routes to this diketone start with succinic acid or its anhydride. A Friedel-Crafts acylation with 2-acetoxy-2-butene in nitrobenzene or with pro-pionyl chloride in nitromethane leads to acylated adducts, which are deacylated in aqueous acids (V.J. Grenda, 1967 L.E. Schick, 1969). A new promising route to substituted cyclopent-2-enones makes use of intermediate 5-nitro-l,3-diones (D. Seebach, 1977). 

Intramolecular Friedel-Crafts substitution has also figured prominently in the synthesis of oxindoles from cx-haloacelanilides. Typical reaction conditions for cyclizalion involve heating with A1CI,[13-17]. 

A less obvious example of a situation in which the success of a synthesis depends on the order of introduction of substituents is illustrated by the preparation of m nitroace tophenone Here even though both substituents are meta directing the only practical synthesis is the one in which Friedel-Crafts acylation is carried out first... 

Friedel-Crafts synthesis TALEIC ANHYDRIDE, MALEIC ACID AND FUMARIC ACID] (Vol 15)... 

The Friedel-Crafts ketone synthesis is of commercial importance in upgrading duoroben2ene for dmg, polymer, and electronic appHcations (Table... 

Table 2. Friedel-Crafts Ketone Synthesis with Fluorobenzene ...

Ketone Synthesis. In the Friedel-Crafts ketone synthesis, an acyl group is iatroduced iato the aromatic nucleus by an acylating agent such as an acyl haUde, acid anhydride, ester, or the acid itself. Ketenes, amides, and nittiles also may be used aluminum chloride and boron ttitiuotide are the most common catalysts (see Ketones). 

Aldehyde Synthesis. Formylation would be expected to take place when formyl chloride or formic anhydride reacts with an aromatic compound ia the presence of aluminum chloride or other Friedel-Crafts catalysts. However, the acid chloride and anhydride of formic acid are both too unstable to be of preparative iaterest. 

Aromatic and heterocycHc compounds are formylated by reaction with dialkyl- or alkylarylformamides in the presence of phosphoms oxychloride or phosgene (Vilsmeier aldehyde synthesis) (125). The Vilsmeier reaction is a Friedel-Crafts type formylation (126), since the intermediate cation formed by the interaction of phosphoms oxychloride with formamide is a typical electrophilic reagent. Ionic addition compounds of formamide with phosgene or phosphoms oxychloride are also known (127). 

Methylcyclobutenyltrimethylsilane undergoes Friedel-Crafts acylation affording the 2-methyl-l-acetylcyclobutene [67223-99-8] which was an intermediate in the synthesis of grandisol [26532-22-9] (176). 

Conjugated dienes, upon complexation with metal carbonyl complexes, are activated for Friedel-Crafts acylation reaction at the akyhc position. Such reactions are increasingly being used in the stereoselective synthesis of acylated dienes. Friedel-Crafts acetylation of... 

Aliphatic Aldehyde Syntheses. Friedel-Crafts-type aUphatic aldehyde syntheses are considerably rarer than those of aromatic aldehydes. However, the hydroformylation reaction of olefins (185) and the related oxo synthesis are effected by strong acid catalysts, eg, tetracarbonylhydrocobalt, HCo(CO)4 (see Oxo process). 

Friedel-Crafts (Lewis) acids have been shown to be much more effective in the initiation of cationic polymerization when in the presence of a cocatalyst such as water, alkyl haUdes, and protic acids. Virtually all feedstocks used in the synthesis of hydrocarbon resins contain at least traces of water, which serves as a cocatalyst. The accepted mechanism for the activation of boron trifluoride in the presence of water is shown in equation 1 (10). Other Lewis acids are activated by similar mechanisms. In a more general sense, water may be replaced by any appropriate electron-donating species (eg, ether, alcohol, alkyl haUde) to generate a cationic intermediate and a Lewis acid complex counterion. 

G-5 Aliphatic Petroleum Resins. Carbocationic polymerization of C-5 feedstreams has been accomptished with various Friedel-Crafts catalyst systems. Table 3 compares the efficiencies of selected Lewis acids ia the polymerization of a typical C-5 stream containing 43 wt % C-5—C-6 diolefias and 47 wt % C-5—C-6 olefins (20). Based on weight percent yield of resia at equimolar coaceatratioas of catalyst (5.62 mmol/100 g), efficieacy follows AICI3 AlBr3 > BF3etherate-H20 > TiCfy > SnCl. The most commonly used catalyst in petroleum resin synthesis is AlCl. ... 

Catalysts used in the polymerization of C-5 diolefins and olefins, and monovinyl aromatic monomers, foUow closely with the systems used in the synthesis of aHphatic resins. Typical catalyst systems are AlCl, AIBr., AlCl —HCl—o-xylene complexes and sludges obtained from the Friedel-Crafts alkylation of benzene. Boron trifluoride and its complexes, as weU as TiCl and SnCl, have been found to result in lower yields and higher oligomer content in C-5 and aromatic modified C-5 polymerizations. 

The earliest reported reference describing the synthesis of phenylene sulfide stmctures is that of Friedel and Crafts in 1888 (6). The electrophilic reactions studied were based on reactions of benzene and various sulfur sources. These electrophilic substitution reactions were characterized by low yields (50—80%) of rather poorly characterized products by the standards of 1990s. Products contained many by-products, such as thianthrene. Results of self-condensation of thiophenol, catalyzed by aluminum chloride and sulfuric acid (7), were analogous to those of Friedel and Crafts. 

Koch Chemical Company is the only U.S. suppHer of all PMBs (except hexamethylbenzene). Its process has the flexibility of producing isodurene, prehnitene, and pentamethylbenzene, should a market develop. Koch s primary process (20) is based on isomerization, alkylation, and disproportionation conducted in the presence of a Friedel-Crafts catalyst. For the synthesis of mesitylene and hemimellitene, pseudocumene is isomerized. If durene, isodurene, or prehnitene and pentamethylbenzene are desired, pseudocumene is alkylated with methyl chloride (see Alkylation Friedel-CRAFTSreactions). 

Uses. Aluminum chloride is used as a catalyst in a wide variety of manufacturing processes, such as the polymerization of light molecular weight hydrocarbons in the manufacture of hydrocarbon resins. Friedel-Crafts reactions (qv) which employ this catalyst are used extensively in the synthesis of agricultural chemicals, pharmaceuticals (qv), detergents, and dyes (12). 

Typical values for mf n are 0.5 to 2.5. Gommercially used bases include sodium hydroxide, potassium hydroxide, calcium hydroxide (lime), magnesium hydroxide, sodium carbonate, sodium alurninate, calcium carbonate, or various mixtures. For certain appHcations, PAG can be made from waste grades of aluminum chloride [7446-70-0] such as spent catalyst solutions from Friedel-Grafts synthesis (see Friedel-Grafts reaction). 

Although all four tocopherols have been synthesized as their all-rac forms, the commercially significant form of tocopherol is i7//-n7i a-tocopheryl acetate. The commercial processes ia use are based on the work reported by several groups ia 1938 (15—17). These processes utilize a Friedel-Crafts-type condensation of 2,3,5-trimethylhydroquinone with either phytol (16), a phytyl haUde (7,16,17), or phytadiene (7). The principal synthesis (Fig. 3) ia current commercial use iavolves condensation of 2,3,5-trimethylhydroquiQone (13) with synthetic isophytol (14) ia an iaert solvent, such as benzene or hexane, with an acid catalyst, such as ziac chloride, boron trifluoride, or orthoboric acid/oxaUc acid (7,8,18) to give the all-rac-acetate ester (15b) by reaction with acetic anhydride. Purification of tocopheryl acetate is readily accompHshed by high vacuum molecular distillation and rectification (<1 mm Hg) to achieve the required USP standard. 

Anthraquinone dyes are derived from several key compounds called dye intermediates, and the methods for preparing these key intermediates can be divided into two types (/) introduction of substituent(s) onto the anthraquinone nucleus, and (2) synthesis of an anthraquinone nucleus having the desired substituents, starting from benzene or naphthalene derivatives (nucleus synthesis). The principal reactions ate nitration and sulfonation, which are very important ia preparing a-substituted anthraquiaones by electrophilic substitution. Nucleus synthesis is important for the production of P-substituted anthraquiaones such as 2-methylanthraquiQone and 2-chloroanthraquiaone. Friedel-Crafts acylation usiag aluminum chloride is appHed for this purpose. Synthesis of quinizatia (1,4-dihydroxyanthraquiQone) is also important. 

Benzimidazolinone, 1,3-dimethyl-Friedel-Crafts reaction, 5, 429 Benzimidazolinone, 1,3-divinyl-synthesis, 5, 393 Benzimidazolinone, 6-methyl-Friedel-Crafts reaction, 5, 429 Benzimidazolin-2-one polymers, 1, 281 Benzimidazolinones alkylation, 5, 390 Friedel-Crafts reaction, 5, 429 Mannich reaction, 5, 390 nitration, 5, 429 reactions, 5, 442... 

Friedel-Crafts cyclization benzo[i]thiophenes from, 4, 873 Ethanol, 2-(4-imidazolyl)-synthesis, 5, 484 Ethanol, (S)-l-phenyl-synthesis, 1, 434 Ethanol, 2-phenyl-isochroman synthesis from, 3, 788 Ether, allyl pyridyl... 

Oxazol-5(2H)-one, 2-benzylidene-4-methyl-tautomerism, 6, 186 Oxazol-5(2ff)-one, 2-methylene-isomerization, 6, 226 Oxazol-5(2H)-one, 2-trifluoromethyl-acylation, 6, 201 Oxazol-5(4ff)-one, 4-allyl-thermal rearrangements, 6, 199 Oxazol-5(4H)-one, 4(arylmethylene)-Friedel-Crafts reactions, 6, 205 geometrical isomerism, 6, 185 Oxazol-5(4ff)-one, 4-benzylidene-2-phenyl-configuration, 6, 185 photorearrangement, 6, 201 Oxazol-5(4ff)-one, 4-benzyl-2-methyl-Friedel-Crafts reactions, 6, 205 Oxazol-5(4ff)-one, 4-methylene-in amino acid synthesis, 6, 203 Oxazol-5(4ff) -one. 2-trifluoromethyl-hydrolysis, 6, 206 Oxazolones... 

---