Epoxides with amines

Mechanisms for reaction of tertiary amines with epoxides are discussed in References 16 and 17. 

The interpretation of the kinetics is based on the mechanisms proposed by Schechter et al.55) and Smith 57), for the reaction of secondary amines with epoxides, extended to include the primary amine reaction. The rate-determining step is assumed to be the reaction of amine, epoxide and hydroxyl or other proton-donor species, HX, to form a termolecular complex, Eq. (3-13). The proposed reaction scheme is ... 

The relative reactivity of secondary and primary amines with epoxide, k2/kt, can affect the overall kinetics. If k2/kj is not close to 0.5 the parameter f in Eqs. (4-7) and (4-13) becomes significant. In this respect there are differences between aliphatic and aromatic or alicyclic amines. For the aliphatic amines the ratio k2/kj is reported to be in the range 0.6-0.7 83 90), whereas for aromatic amines values in the range 0.2 to 0.5 have been observed 90 9S). For the reaction of BADGE with DDS, Dobas et al. 94) reported a value of 0.21 for k2/k, at 80 °C. This factor is likely to account for part of the observed non-linearity in reduced rate plots at higher levels of conversion. 

Instrumental analytical methods including HPLC, NMR and FT-IR have enabled the course of the reaction to be delineated by analysing the sol and gel fractions over time. In Section 1.2.1 the individual amine-epoxy reactions were presented, since the first stage of the reaction with a primary amine involves chain extension. This reaction competes with crosslinking since the reaction of the primary amine with epoxide is much faster than the reaction of the secondary amine. It is the latter reaction that results in branching of the chain and thus the formation of the first crosslinks. 

Reactions of secondary amines with epoxide occur in a similar way to those of primary amines, though often at a significantly slower rate due to steric hindrance. 

Tritium labelled compounds can also be used as true tracers for following the rates of homogeneous reactions. Thus, in the reaction of amines with epoxides, one can label the amine and by taking samples at fixed time intervals, quenching and subjecting them to radio-HPLC one can follow the disappearance of amine, the increase in the formation of a 1 1 complex and in some cases, the appearance of further complexes until reaction is complete (Fig. With so much information becoming available it is... 

Diamines, a well-studied co-reactant with epoxy, are tetrafunctional where each amine hydrogen can react. The reactions of primary amine and secondary amine with epoxide are illustrated in equations 1 and 2, respectively. The heat of reaction Aifrxn for epoxy-amine is 106 kJ/mol ( 25.5 kcal/mol) for reaction with... 

PROBLEM 7.34 Another nucleophilic synthesis of amines involves the reaction of simple amines with epoxides. Write a mechanism for the reaction below. 

A similar protocol was used by Siegel and coworkers [25] in the purification of products from reductive aminations, epoxide openings using amines and urea formation and by Chucholowski et al. [26] in the synthesis of thiazole libraries. A library of 48 ethanolamines in an 8 x 6 array prepared by the monoalkylation of amines with epoxides (Figure 11) was disclosed by Shuker et al. [27]. The synthetic protocol involved the in situ silylation of the amine with bis-(trimethylsilyl)acetamide, reaction with excess epoxide followed by SCX ion-exchange chromatography. 

Mojtahedi et al. (1999) obtained high yields of P-amino alcohols from the reaction of primary and secondary amines with epoxides in the presence of montmoril-lonite KIO clay, under solvent-free conditions and microwave irradiation. 

Amines also react with epoxides at the less substituted carbon atom. As a slightly more testing problem, suggest a synthesis of the alcohol (TM 165) whose derivatives are used in disinfectants ("phemeiide" etc.). 

Primary and secondary amines also react with epoxides (or in situ produced episulfides )r aziridines)to /J-hydroxyamines (or /J-mercaptoamines or 1,2-diamines). The Michael type iddition of amines to activated C—C double bonds is also a useful synthetic reaction. Rnally unines react readily with. carbonyl compounds to form imines and enamines and with carbo-tylic acid chlorides or esters to give amides which can be reduced to amines with LiAlH (p. Ilf.). All these reactions are often applied in synthesis to produce polycyclic alkaloids with itrogen bridgeheads (J.W. Huffman, 1967) G. Stork, 1963 S.S. Klioze, 1975). 

Nucleophilic ring opening of epoxides by ammonia (Section 16 12) The strained ring of an epoxide is opened on nucleo philic attack by ammonia and amines to give 3 ammo alcohols Azide ion also re acts with epoxides the products are p azido alcohols... 

AH of the amine hydrogens are replaced when MDA or PMDA reacts with epoxides to form amine based polyols. These polyols can be used in reactions with isocyanates to form urethanes or with additional epoxide to form cross-linked thermo set resins. 

All lene Oxides and Aziridines. Alkyleneamines react readily with epoxides, such as ethylene oxide [75-21-8] (EO) or propylene oxide [75-56-9] (PO), to form mixtures of hydroxyalkyl derivatives. Product distribution is controlled by the amine to epoxide mole ratio. If EDA, which has four reactive amine hydrogens, reacts at an EDA to EO mole ratio which is greater than 1 4, a mixture of mono-, di-, tri,-, and tetrahydroxyethyl derivatives of EDA are formed. A 10 1 EDA EO feed mole ratio gives predominandy 2-hydroxyethylethylenediamine [111-41-1], the remainder is a mixture of bis-(2-hydroxyethyl)ethylenediamines (7). If the reactive NH to epoxide feed mole ratio is less than one and, additionally, a strong basic catalyst is used, then oxyalkyl derivatives, like those shown for EDA and excess PO result (8,9). 

The most important Lewis bases are tertiary amines or polyamines converted into tertiary amines upon reaction with epoxide groups. 

In terms of cost, the effectiveness of the catalytic cycle in the ring closure makes this process economical in palladium. The first three steps in the reaction sequence -- ring opening of an epoxide by a Grignard reagent, converison of an alcohol to an amine with inversion, and sulfonamide formation from the amine — are all standard synthetic processes. 

Ethylene oxide is a highly active intermediate. It reacts with all compounds that have a labile hydrogen such as water, alcohols, organic acids, and amines. The epoxide ring opens, and a new compound with a hydroxyethyl group is produced. The addition of a hydroxyethyl group increases the water solubility of the resulting compound. Eurther reaction of ethylene oxide produces polyethylene oxide derivatives with increased water solubility. 

Aliphatic polyamines, amine adducts and polyamides react with epoxide resins at normal temperatures to give complexes with outstanding chemical resistance. Paints based on this type of reaction must be supplied in two separate containers, one containing the epoxide resin and the other the curing agent , the two being mixed in prescribed proportions immediately before use. 

Phosphoric acid diesters are prepared by treating a liquid slurry of phosphate monoester with epoxides in the presence of alkali compounds. Thus a mixture of monolauryl phosphate sodium salt and triethyl amine in water was treated with glycidol at 80°C for 8 h to give 98% lauryl(2,3-dihydroxypropyl)phosphate sodium salt [13]. 

Allyl silanes react with epoxides, in the presence of Bp3-OEt2 to give 2-allyl alcohols. The reaction of a-bromo lactones and CH2=CHCH2Si SiMe3)3 and AIBN leads to the a-allyl lactone. " Benzyl silanes coupled with allyl silanes to give ArCH2—R derivatives in the presence of VO(OEt)Cl2 " and allyltin compounds couple with allyl silanes in the presence of SnCU. " Allyl silanes couple to the a-carbon of amines under photolysis conditions. ... 

In a total synthesis of inhibitors of this kind, the following methods have so far been employed successfully (a) reaction of a cyclohexenyl halide with an amine, (b) coupling of an amine with an epoxide, and (c) condensation of an amine with ketone and reduction of the resulting Schiff base (reductive alkylation of an amino sugar). 

C. Reactions not involving P=0 or P=S Groups.—Enamine phosphine oxides (45) have been prepared by the addition of amines to 1-alkynyl-phosphine oxides, and the reactions of their anions with various electrophiles have been reported. - With ketones a Wittig-type reaction leads to the formation of a/3-unsaturated ketones, in 53—70% yield, while with epoxides cyclopropyl ketimines are formed. A Diels-Alder reaction of l-phenyl-A -phospholen-l-oxide (46) with 1,4-diacetoxybutadiene has been used in the preparation of l-phenyl-benzo[/>]phosphole (47), as... 

Heteropoly acids can be synergistically combined with phase-transfer catalysis in the so-called Ishii-Venturello chemistry for oxidation reactions such as oxidation of alcohols, allyl alcohols, alkenes, alkynes, P-unsaturated acids, vic-diols, phenol, and amines with hydrogen peroxide (Mizuno et al., 1994). Recent examples include the epoxidations of alkyl undecylenates (Yadav and Satoskar, 1997) and. styrene (Yadav and Pujari, 2000). 

An amino alcohol can be formed in situ by the reaction of an iV-formylpiperizine 79 with epoxide 78 which then can be induced to cyclize to give the spiroaziridinium salt 80 (Equation 17) <2004TL4175>. The spiroaziridinium was not isolated but instead trapped by reaction with an amine nucleophile (cf. Section 12.20.6.1). 

---