Egg-shell

The egg shell is 94% calcium carbonate [471-34-17, CaCO, 1% calcium phosphate [7758-23-8] and a small amount of magnesium carbonate [546-93-0]. A water-insoluble keratin-type protein is found within the shell and in the outer cuticle coating. The pores of the shell allow carbon dioxide and water to escape during storage. The shell is separated from the egg contents by two protein membranes. The air cell formed by separation of these membranes increases in size because of water loss. The air cell originally forms because of the contraction of the Hquid within the egg shell when the temperature changes from the body temperature of the hen at 41.6°C to a storage temperature of the egg at 7.2°C. 

Eier, n.pf. eggs, -albumin, n. egg albumin, ovalbumin, -dotter, m. yolk of eggs, -drtise, /. corpus luteum. -frucht,/. eggplant. gang, m. oviduct, -ol, n. egg-yolk oil, egg oil. -pulver, n. egg powder, custard powder, -schale, /. egg shell, -schalenglanz, m. eggshell luster. Stein, m. odlite, egg stone. 

Although the Langelier index is probably the most frequently quoted measure of a water s corrosivity, it is at best a not very reliable guide. All that the index can do, and all that its author claimed for it is to provide an indication of a water s thermodynamic tendency to precipitate calcium carbonate. It cannot indicate if sufficient material will be deposited to completely cover all exposed metal surfaces consequently a very soft water can have a strongly positive index but still be corrosive. Similarly the index cannot take into account if the precipitate will be in the appropriate physical form, i.e. a semi-amorphous egg-shell like deposit that spreads uniformly over all the exposed surfaces rather than forming isolated crystals at a limited number of nucleation sites. The egg-shell type of deposit has been shown to be associated with the presence of organic material which affects the growth mechanism of the calcium carbonate crystals . Where a substantial and stable deposit is produced on a metal surface, this is an effective anticorrosion barrier and forms the basis of a chemical treatment to protect water pipes . However, the conditions required for such a process are not likely to arise with any natural waters. 

Most commonly, chitin means the skeletal material of invertebrates. At least 1.10 kg of chitin are constantly present in the biosphere. Q -Chitin occurs in the calyces of hydrozoa, the egg shells of nematodes and rotifers, the radulae... 

However, there may be good reasons why a catalyst should not consist of particles that are too small, as we saw in the beginning of this chapter, e.g. to avoid pressure gradients in the reactor. Based on an analysis such as the above, one can decide whether it makes sense to use support particles that contain a homogeneous distribution of the catalytic phase. With expensive noble metals, one might perhaps decide to use an egg-shell type of arrangement, where the noble metal is only present on the outside of the particles. 

In order to probe the influence of Au and KOAc on the vinyl acetate synthesis chemistry, four different catalysts were synthesized. All of these catalysts were prepared in a manner exemplified in prior patent technology [Bissot, 1977], and each contained the same palladium loading in an egg-shell layer on the surface of a spherical silica support. The palladium content in the catalyst was easily controlled by adjusting the solution strength of palladium chloride (PdClj) added to the porous silica beads prior to its precipitation onto the support by reaction with sodium metasilicate (Na SiOj). The other two catalyst components (Au and KOAc) were either present or absent in order to complete the independent evaluation of their effect on the process chemistry, e.g., (1) Pd-i-Au-hKOAc, (2) Pd-i-KOAc, (3) Pd-hAu, and (4) Pd only. 

For Pt75Ni25 the optimal structure is an egg-shell of Pt covering a Ni-rich core. 

The catalytic applications of Moiseev s giant cationic palladium clusters have extensively been reviewed by Finke et al. [167], In a recent review chapter we have outlined the potential of surfactant-stabilized nanocolloids in the different fields of catalysis [53]. Our three-step precursor concept for the manufacture of heterogeneous egg-shell - nanocatalysts catalysts based on surfactant-stabilized organosols or hydrosols was developed in the 1990s [173-177] and has been fully elaborated in recent time as a standard procedure for the manufacture of egg-shell - nanometal catalysts, namely for the preparation of high-performance fuel cell catalysts. For details consult the following Refs. [53,181,387]. 

Figure 3.28. Four types of active phase distribution, a uniform, b egg-shell, c egg-white, and d egg-yolk.

Two ways to reduce the diffusion length in TBRs are 1) use of smaller catalyst particles, or 2) use of an egg-shell catalyst. The first remedy, however, will increase pressure drop until it becomes unacceptable, and the second reduces the catalyst load in the reaction zone, making the loads of the TBR and the MR comparable. For instance, the volumetric catalyst load for a bed of 1 mm spherical particles with a 0.1 mm thick layer of active material is 0.27. The corresponding load for a monolithic catalyst made from a commercial cordierite structure (square cells, 400 cpsi, wall thickness 0.15 mm), also with a 0.1 mm thick layer of active material, is 0.25. 

Various finishes can be achieved — gloss, satin (or egg-shell) or matt. This is accomplished by the addition of particles of size 1-5 pm of, for example, silica, china clay or the white pigment, TiCK The degree of mattness depends on various factors, such as particle size, surface treatment of the particles, rate of film formation, and the polymer composition, e.g., urethane/acrylate compared with epoxy/acrylate. The former requires smaller particles larger particles cannot be used as they create a rough surface. 

Brydon, L.J., Gooday, G.W., Chappell, L.H. and King, T.P. (1987) Chitin in egg shells of Onchocerca gibsoni and Onchocerca volvulus. Molecular and Biochemical Parasitology 25, 267—272. 

Wharton, D. (1983) The production and functional morphology of helminth egg-shells. Parasitology 86, 85-97. 

Good insulation for the poultry house is not only important to prevent frozen water in the cold season, but also to keep temperatures down on hot days in summer. High temperatures reduce the well-being of the hens and reduce egg shell quality, resulting in more broken eggs (Yahav et al., 2000). 

Use only eggs with good egg shell quality (from hens up to 40 weeks of age). 

Colouring acts as a preservative (seals porous egg shell). 

Some of the important compounds containing the group IA and IIA metals are the carbonates, nitrates, sulfates, and phosphates. We have already mentioned the mineral trona as the source of sodium carbonate. Calcium carbonate is found in many forms that include chalk, calcite, aragonite, and marble, as well as in egg shells, coral, and seashells. In addition to its use as a building material, calcium phosphate is converted into fertilizers in enormous quantities (see Chapter 14). 

Richter, M., Trunschke, A., Bentrup, U., Brzezinka, K.W., Schreier, E., Schneider, M., Pohl, M.M., and Fricke, R. 2002. Selective catalytic reduction of nitric oxide by ammonia over egg-shell MnOx/NaY composite catalysts. J. Catal. 206 98-113. 

Calcium carbonate (calcite, aragonite, Exoskeletons (mollusc and egg shells ... 

Steam reforming is a heterogeneously catalyzed process, with nickel catalyst deposited throughout a preformed porous support. It is empirically observed in the industry, that conversion is proportional to the geometric surface area of the catalyst particles, rather than the internal pore area. This suggests that the particle behaves as an egg-shell type, as if all the catalytic activity were confined to a thin layer at the external surface. It has been demonstrated by conventional reaction-diffusion particle modelling that this behaviour is due to... 

Subsequent to the simulations reported in Dixon et al. (2003), some runs were carried out in which the virtual stacking was used, to provide a similar length of heated tube as in the runs without heat sinks, for comparison purposes. Some results for the third segment are given in Fig. 31, which shows a horizontal plane at the vertical midpoint of the WS and a vertical plane at the horizontal midpoint of the WS, under inlet tube conditions. The level of particle activity was rcut/rv — 0.95, which was closest to the egg-shell picture. 

---