Aldehydes palladium catalysts

Aromatic Aldehydes. Carbon monoxide reacts with aromatic hydrocarbons or aryl haHdes to yield aromatic aldehydes (see Aldehydes). The reaction of equation 24 proceeds with yields of 89% when carried out at 273 K and 0.4 MPa (4 atm) using a boron trifluoride—hydrogen fluoride catalyst (72), whereas conversion of aryl haHdes to aldehydes in 84% yield by reaction with CO + H2 requires conditions of 423 K and 7 MPa (70 atm) with a homogeneous palladium catalyst (73) and also produces HCl. 

This reaction is favored by moderate temperatures (100—150°C), low pressures, and acidic solvents. High activity catalysts such as 5—10 wt % palladium on activated carbon or barium sulfate, high activity Raney nickel, or copper chromite (nonpromoted or promoted with barium) can be used. Palladium catalysts are recommended for the reduction of aromatic aldehydes, such as that of benzaldehyde to toluene. 

Rosenmund reaction is the action between acid chloride and hydrogen in the presence of palladium catalyst to produce aldehydes... 

Reduction of unsaturated carbonyl compounds to the saturated carbonyl is achieved readily and in high yield. Over palladium the reduction will come to a near halt except under vigorous conditions (73). If an aryl carbonyl compound, or a vinylogous aryl carbonyl, such as in cinnamaldehyde is employed, some reduction of the carbonyl may occur as well. Carbonyl reduction can be diminished or stopped completely by addition of small amounts of potassium acetate (i5) to palladium catalysts. Other effective inhibitors are ferrous salts, such asferroussulfate, at a level of about one atom of iron per atom of palladium. The ferrous salt can be simply added to the hydrogenation solution (94). Homogeneous catalysts are not very effective in hydrogenation of unsaturated aldehydes because of the tendencies of these catalysts to promote decarbonylation. 

Fischer s original method for conversion of the nitrile into an aldehyde involved hydrolysis to a carboxylic acid, ring closure to a cyclic ester (lactone), and subsequent reduction. A modern improvement is to reduce the nitrile over a palladium catalyst, yielding an imine intermediate that is hydrolyzed to an aldehyde. Note that the cyanohydrin is formed as a mixture of stereoisomers at the new chirality center, so two new aldoses, differing only in their stereochemistry at C2, Tesult from Kiliani-Fischer synthesis. Chain extension of D-arabinose, for example, yields a mixture of D-glucose and o-mannose. 

The N-substituted aminoacids required could be prepared by microwave-assisted reductive amination of aminoacid methyl esters with aldehydes, and although in the Westman report soluble NaBH(OAc)3 was used to perform this step, other reports have shown how this transformation can be performed in using polymer-supported borohydrides (such as polymer-supported cyanoborohydride) under microwave irradiation [90]. An additional point of diversity could be inserted by use of a palladium-catalyzed reaction if suitably substituted aldehydes had been used. Again, these transformations might eventually be accomplished using supported palladium catalysts under microwave irradiation, as reported by several groups [91-93]. 

Other nucleophiles add to conjugated systems to give Michael-type products. Aniline derivatives add to conjugated aldehydes in the presence of a catalytic amount of DBU (p. 488). Amines add to conjugated esters in the presence of InCla, La(OTf)3, or YTb(OTf)3 at 3kbar, for example, to give P-amino esters. This reaction can be initiated photochemically. An intramolecular addition of an amine unit to a conjugated ketone in the presence of a palladium catalyst, or... 

Similar reactions have been carried out on acetylene. Aldehydes add to alkynes in the presence of a rhodium catalyst to give conjugated ketones. In a cyclic version of the addition of aldehydes, 4-pentenal was converted to cyclopen-tanone with a rhodium-complex catalyst. In the presence of a palladium catalyst, a tosylamide group added to an alkene unit to generate A-tosylpyrrolidine derivatives. ... 

The Harmata group s initial report concerned a one-pot, one-operation procedure <99AG(E)2419> for the synthesis of enantiomerically pure 2,1-benzothiazines via the Buchwald-Hartwig reaction reported by Bolm <98TL5731 OOJOC169> for sulfoximine N-arylation. For example, treatment of ortho-bromobenzaldehyde 78 with enantiomerically pure N-H sulfoximine 77a in the presence of a palladium catalyst and base afforded the benzothiazine 79 in 78% yield (Scheme 22). Both C-N bond formation and condensation occurred during the reaction, a phenomenon that appears general for aldehydes like 78. 

The second characteristic reaction catalyzed by palladium catalysts is cocyclization of butadiene with the C=0 bonds of aldehydes and the C=N bonds of isocyanates and Schiff bases to form six-membered heterocyclic compounds (19) with two vinyl groups, as expressed by the following general scheme ... 

Formation of a bis-allylated product of 4-nitrobenzoyl chloride by the reaction with allyltrimethyltin in the presence of a benzylpalladium(ll) complex was observed by Stille and co-workers in 1983.4 Trost and King also reported allylation of aldehydes by allyltin reagents in 1990.456 However, the precise mechanism was unclear until the extended studies were performed by Yamamoto and co-workers since 1995.4S7,4S7a 4S7 Aldehydes and imines react with allyltin reagents in the presence of a palladium catalyst (Equations (95) and (96)), and imines are chemoselectively allylated in the presence of aldehydes (Equation (97)).4S7,4S7l 4 b Mechanistic studies using NMR spectroscopy proved that bis-7t-allylpalladium complex 203 is a key nucleophilic intermediate (Figure 3). 

A more satisfactory sequence, which also starts with enantioenriched propargylic mesylates, generates the allenylindium intermediate by oxidative transmetallation of an allenylpalladium precursor with Ini. This catalytic process takes place in the presence of an aldehyde. The reaction employs 5-10 mol% of the palladium catalyst and a stoichiometric quantity of Ini. Based on the stereochemistry of the starting... 

Synthesis of aldehydes from alcohols is an important transformation in several applications. In small scale oxidations still chromic acid is being used as a stoichiometric oxidant of alcohols, which leads to a large amount of toxic waste and it is also expensive. Catalytic routes have been reported using palladium catalyst [18], or TEMPO (see also Figure 15.13) as a radical catalyst for the oxidation of alcohols [19], or combinations of TEMPO and copper [20] related work is mentioned in the references of these articles. The mechanism of... 

Grignard reaction and similar transformations allow C-C bond formation without a palladium catalyst. Grignard reagents and organolithium compounds are very versatile carbanion sources used in the synthesis of acyclic, heterocychc and carbo-cychc compounds. The esters, ketones and aldehydes are more stable when the reaction takes place on solid supports than in the hquid-phase, because this immo-bihzed components are not so sensitive towards water or oxygen. In the total synthesis of (S)-zearalenone (155) on solid supports the Grignard reaction is one of the key steps (Scheme 3.16) [120]. 

Hydrogenation reduction of acid chloride to aldehyde using BaS04-poisoned palladium catalyst. Without poison, the resulting aldehyde may be further reduced to alcohol. 

Palladium catalysts are more often modified for special selectivities than platinum catalysts. Palladium prepared by reduction of palladium chloride with sodium borohydride Procedure 4, p. 205) is suitable for the reduction of unsaturated aldehydes to saturated aldehydes [i7]. Palladimn on barium sulfate deactivated with sulfur compounds, most frequently the so-called quinoline-5 obtained by boiling quinoline with sulfur [34], is suitable for the Rosenmund reduction [i5] (p. 144). Palladium on calcium carbonate deactivated by lead acetate Lindlar s catalyst) is used for partial hydrogenation of acetylenes to cw-alkenes [36] (p. 44). 

The original amidocarbonylation reaction catalyzed by HCo(CO)4, generated in situ from Co2(CO)8, required very high pressures (>200 atm) of CO and H2, which made the scope of this process rather limited. However, the use of palladium catalysts for this process has substantially expanded the scope of the reaction. The Pd-catalyzed amidocarbonylation of aldehydes proceeds under CO pressure (60 atm) in the presence of water, a catalytic amount of acid, and a... 

Initial studies showed that the encapsulated palladium catalyst based on the assembly outperformed its non-encapsulated analogue by far in the Heck coupling of iodobenzene with styrene [7]. This was attributed to the fact that the active species consist of a monophosphine-palladium complex. The product distribution was not changed by encapsulation of the catalyst. A similar rate enhancement was observed in the rhodium-catalyzed hydroformylation of 1-octene (Scheme 8.1). At room temperature, the catalyst was 10 times more active. For this reaction a completely different product distribution was observed. The encapsulated rhodium catalyst formed preferentially the branched aldehyde (L/B ratio 0.6), whereas usually the linear aldehyde is formed as the main product (L/B > 2 in control experiments). These effects are partly attributed to geometry around the metal complex monophosphine coordinated rhodium complexes are the active species, which was also confirmed by high-pressure IR and NMR techniques. 

Arene(tricarbonyl)chromium complexes, 19 Nickel boride, 197 to trans-alkenes Chromium(II) sulfate, 84 of anhydrides to lactones Tetrachlorotris[bis(l,4-diphenyl-phosphine)butane]diruthenium, 288 of aromatic rings Palladium catalysts, 230 Raney nickel, 265 Sodium borohydride-1,3-Dicyano-benzene, 279 of aryl halides to arenes Palladium on carbon, 230 of benzyl ethers to alcohols Palladium catalysts, 230 of carboxylic acids to aldehydes Vilsmeier reagent, 341 of epoxides to alcohols Samarium(II) iodide, 270 Sodium hydride-Sodium /-amyloxide-Nickel(II) chloride, 281 Sodium hydride-Sodium /-amyloxide-Zinc chloride, 281 of esters to alcohols Sodium borohydride, 278 of imines and related compounds Arene(tricarbonyl)chromium complexes, 19... 

---