Propyl n-valerate

Place a mixture of 25 5 g. of n-valerio acid (Sections 111,83 and 111,84), 30 g. (37 -5 ml.) of dry n-propyl alcohol, 50 ml. of sodium-dried benzene and 10 g. (5-5 ml.) of concentrated sulphuric acid in a 250 ml. round-bottomed flask equipped with a vertical condenser, and reflux for 36 hours. Pour into 250 ml. of water and separate the upper layer. Extract the aqueous layer with ether, and add the extract to the benzene solution. Wash the combined extracts with saturated sodium bicarbonate solution until effervescence ceases, then with water, and dry with anhydrous magnesium sulphate. Remove the low boiling point solvents by distillation (use the apparatus of Fig. II, 13,4 but with a Claisen flask replacing the distilling flask) the temperature will rise abruptly and the fi-propyl n-valerate will pass over at 163-164°. The yield is 28 g. 

isoPROPYL LACTATE (Ion Exchange Resin Catalyst Method) 

Place a mixture of 53 g. of A.R. lactic acid (85-88 per cent, acid), 75 g. (85-5 ml.) of commercial anhydrous isopropyl alcohol, 300 ml. of benzene and 20 g. of Zeo-Karb 225/H (1) in a 700 ml. bolt-head flask, equipped with an automatic water separator (e.g., a large modified Dean and Stark apparatus with a stopcock at the lower end, see Fig. Ill, 126, 1) carrying an efficient reflux condenser at its upper end, and a mercury-sealed stirrer (alternatively, the hquid-sealed stirrer shown in Fig. 11,7,11, c. may be used). Reflux the mixture, with stirring, on a steam bath for 5 hours or until water no longer collects in appreciable amount in the water separator run off the water from time to time. Filter off the resin at the pump and wash it with two 25 ml. portions of benzene. Shake the combined filtrate and washings with about 5 g. of precipit-ated calcium 

Furfuryl acetate. Reflux a mixture of 39 2 g. (34-8 ml.) of redistilled furfuryl alcohol, 48 g. of glacial acetic acid, 150 ml. of benzene and 20 g. of Zeo-Karb 225/H in a 500 ml. bolt-head flask, using the apparatus described under iaoPropyl Lactate. After 3 hours, when the rate of collection of water in the water separator is extremely slow, allow to cool, separate the resin by suction filtration, and wash it with three 15 ml. portions of benzene. Remove the benzene, etc., from the combined filtrate and washings under reduced pressure (water pump) and then collect the crude ester at 74-90°/10 mm. a small sohd residue remains in the flask. Redistil the crude ester from a Claisen flask with fractionating side arm pure furfuryl acetate passes over at 79-80°/17 mm. The yield is 14 -5 g. 

Preparation of silver maleate. Dissolve 65 g. of pure maleic acid (Section 111,143) in the calculated quantity of carefully standardised 3-5N aqueous ammonia solution in a 1-htre beaker and add, whilst stirring mechanically, a solution of 204 g. of silver nitrate in 200 ml. of water. Filter oflf the precipitated silver maleate at the pump, wash it with distilled water, and press well with the back of a large flat glass stopper. Dry in an electric oven at 50-60° to constant weight. The yield of the dry silver salt is 150 g. Store in a vacuum desiccator in the dark. 

Ethyl maleate of almost equal purity may be obtained by refluxing a mixture of 29 g. of pure maleic acid, 37 g. (47 ml.) of absolute ethyl alcohol, 95 ml. of sodium-dried benzene and 4 ml. of concentrate sulphuric acid for 12 hours. The ester is isolated as described for Diethyl Adipate (Section 111,100). The yield of diethyl maleate, b.p. 219-220°, is 26 g. 

Place a mixture of 53 g. of A.R. lactic acid (85-88 per cent, acid), 

---

Valeric acid n-Propyl alcohol n-Propyl n-valerate... 

Synonyms Isobutyl pentanoate Isobutyl valerinate 2-Methylpropyl valerate 2-Methyl-1-propyl n-valerate Pentanoic acid, 2-methylpropyl ester Valeric acid, isobutyl ester Empirical C9H18O2... 

Methylpropyl valerate 2-Methyl-1-propyl n-valerate. See Isobutyl valerate... 

CAS 141-06-0 EINECS/ELINCS 205-452-4 Synonyms Pentanoic acid, propyl ester Propyl pentanoate n-Propyl pentanoate n-Propyl n-valerate Valeric acid, propyl ester... 

---