Oxidative carbonylations alcohols

As a unique reaction of Pd(II), the oxidative carbonylation of alkenes is possible with Pd(ll) salts. Oxidative carbonylation is mechanistically different from the hydrocarboxylation of alkenes catalyzed by Pd(0), which is treated in Chapter 4, Section 7.1. The oxidative carbonylation in alcohol can be understood in the following way. The reaction starts by the formation of the alkoxy-carbonylpalladium 218. Carbopalladation of alkene (alkene insertion) with 218 gives 219. Then elimination of /3-hydrogen of this intermediate 219 proceeds to... 

The first report of oxidative carbonylation is the reaction of alkenes with CO in benzene in the presence of PdCh to afford the /3-chloroacyl chloride 224[12,206]. The oxidative carbonylation of alkene in alcohol gives the q, f3-unsaturated ester 225 and /3-alkoxy ester 226 by monocarbonylation, and succinate 111 by dicarbonylation depending on the reaction conditions[207-209]. The scope of the reaction has been studied[210]. Succinate formation takes... 

Aconitatc was obtained as a minor product in the carbonylation of propar-gyl alcohol[479]. However, in the two-step synthesis of methyl aconitate (536) from propargyl alcohol in 70% overall yield, the first step is the oxidative carbonylation under CO and air using Pdli and KI to giNe dimethyl hydro-xymethylbutenedioate (535), which is carbonylated further to give trimethyl aconitate (536) by u.sc of [Pd(Tu)4jl2 as a catalyst[480]. 

As an application of maleate formation, the carbonylation of silylated 3-butyn-l-ol affords the 7-butyrolactone 539[482], Oxidative carbonylation is possible via mercuration of alkynes and subsequent Lransmetallation with Pd(II) under a CO atmosphere. For example, chloromercuration of propargyl alcohol and treatment with PdCF (1 equiv.) under 1 atm of CO in THF produced the /3-chlorobutenolide 540 in 96% yield[483]. Dimethyl phenylinale-ate is obtained by the reaction of phenylacetylene, CO, PdCU, and HgCl2 in MeOH[484,485]. 

Oxidative carbonylation of alcohols with PdCh affords the carbonate 572 and oxalate 573(512-514]. The selectivity of the mono- and dicarbonylation depends on the CO pressure and reaction conditions. In order to make the reaction catalytic, Cu(II) and Fe(III) salts are used. Under these conditions, water is formed and orthoformate is added in order to trap the water. Di-/-butyl peroxide is also used for catalytic oxidative carbonylation to give carbonates and oxalates in the presence of 2,6-dimetliylpyridine(515]. 

Carbamates are produced by the oxidative carbonylation of amines in alcohol, and active research on the commercial production of carbamates as a precursor of isoyanates based on this reaction has been carried out. As an example, ethyl phenylcarbamate (582) is produced in a high yield (95%) with... 

The final step can involve introduction of the amino group or of the carbonyl group. o-Nitrobenzyl aldehydes and ketones are useful intermediates which undergo cyclization and aromatization upon reduction. The carbonyl group can also be introduced by oxidation of alcohols or alkenes or by ozonolysis. There are also examples of preparing indoles from o-aminophcnyl-acetonitriles by partial reduction of the cyano group. 

Many biological processes involve oxidation of alcohols to carbonyl compounds or the reverse process reduction of carbonyl compounds to alcohols Ethanol for example is metabolized m the liver to acetaldehyde Such processes are catalyzed by enzymes the enzyme that catalyzes the oxidation of ethanol is called alcohol dehydrogenase... 

A major difference between alcohols and thiols concerns their oxidation We have seen earlier m this chapter that oxidation of alcohols gives compounds having carbonyl groups Analogous oxidation of thiols to compounds with C=S functions does not occur Only sulfur is oxidized not carbon and compounds containing sulfur m various oxida tion states are possible These include a series of acids classified as sulfemc sulfimc and sulfonic according to the number of oxygens attached to sulfur... 

Oxidative Carbonylation of Ethylene—Elimination of Alcohol from p-Alkoxypropionates. Spectacular progress in the 1970s led to the rapid development of organotransition-metal chemistry, particularly to catalyze olefin reactions (93,94). A number of patents have been issued (28,95—97) for the oxidative carbonylation of ethylene to provide acryUc acid and esters. The procedure is based on the palladium catalyzed carbonylation of ethylene in the Hquid phase at temperatures of 50—200°C. Esters are formed when alcohols are included. Anhydrous conditions are desirable to minimize the formation of by-products including acetaldehyde and carbon dioxide (see Acetaldehyde). 

The elimination of alcohol from P-alkoxypropionates can also be carried out by passing the alkyl P-alkoxypropionate at 200—400°C over metal phosphates, sihcates, metal oxide catalysts (99), or base-treated zeoHtes (98). In addition to the route via oxidative carbonylation of ethylene, alkyl P-alkoxypropionates can be prepared by reaction of dialkoxy methane and ketene (100). 

Chromium compounds decompose primary and secondary hydroperoxides to the corresponding carbonyl compounds, both homogeneously and heterogeneously (187—191). The mechanism of chromium catalyst interaction with hydroperoxides may involve generation of hexavalent chromium in the form of an alkyl chromate, which decomposes heterolyticaHy to give ketone (192). The oxidation of alcohol intermediates may also proceed through chromate ester intermediates (193). Therefore, chromium catalysis tends to increase the ketone alcohol ratio in the product (194,195). 

The oxidative carbonylation of styrene with carbon monoxide, oxygen, and an aUphatic alcohol in the presence of a palladium salt, a copper salt, and sodium propionate also provides the requisite cinnamate. 

Dimethyl sulfoxide reacts with trifluoroacetic anhydride at low tempera ture to give a complex that is an efficient reagent for the oxidation of alcohols to carbonyl compounds [40 41] This reagent can be used to oxidize primary and secondary aliphatic alcohols, cycloalkyl alcohols, and allylic, homoallylic, ben-zylic, acetylenic, and steroidal alcohols (equation 19)... 

Perhaps the most important reaction of alcohols is their oxidation to carbonyl compounds. Primary alcohols yield either aldehydes or carboxylic acids, secondary alcohols yield ketones, but tertiary alcohols are not normally oxidized. Pyridinium chlorochromate (PCC) in dichloromethane is often used for oxidizing primary alcohols to aldehydes and secondary alcohols to ketones. A solution of Cr03 in aqueous acid is frequently used for oxidizing primary alcohols to carboxylic acids and secondary alcohols to ketones. 

Oxidation of alcohols to carbonyls (2° alcohols can be selectively oxidized)... 

Oxoreductases include enzymes such as dehydrogenases, oxidases and peroxidases which catalyse transformations such as oxidation of alcohols to carbonyls and dehydrogenation of functionalized alkanes to alkenes. 

Finally, phthalocyanine iron catalysts were also used for the oxidation of alcohols to yield corresponding carbonyl compounds with nonbenign hypervalent iodine oxidants [147]. 

The oxidation of alcohols to carbonyl compounds by permanganate proceeds most rapidly in basic solution and it is with this medium that the majority of kinetic studies have been performed. 

M-NHC catalysts in this area. Metal catalysed carbonylation also provides an alternative synthetic ronte to the prodnction of materials that traditionally reqnire highly toxic precnrsors, like phosgene. This section discnsses carbonylation of aryl hahdes, oxidative carbonylation of phenolic and amino componnds, carbonylation of aryl diazoninm ions, alcohol carbonylation, carbonylative amidation, and copolymerisation of ethylene and CO. 

Oxidative carbonylation generates a number of important compounds and materials such as ureas, carbamates, 2-oxazolidinones, and aromatic polycarbonates. The [CuX(IPr)] complexes 38-X (X = Cl, Br, I) were tested as catalysts for the oxidative carbonylation of amino alcohols by Xia and co-workers [43]. Complex 38-1 is the first catalyst to selectively prepare ureas, carbamates, and 2-oxazolidinones without any additives. The important findings were the identity of the counterion and that the presence of the NHC ligand influenced the conversions. 2-Oxazohdinones were formed from primary amino alcohols in 86-96% yield. Complex 38-1 also catalysed the oxidative carbonylation of primary amines to ureas and carbamates. n-Propylamine, n-butylamine, and t-butylamine were transformed into the... 

The oxidation of alcohols to the corresponding carbonyl compounds is one of the key reactions in organic synthesis and nnmerous methods have been developed over the years to accomplish this transformation [16], A general mechanism for Pd-catalysed aerobic oxidation is shown below (Scheme 10.5). 

Kim, S.S. St Rajagopal, G. (2004) Efficient Aerobic Oxidation of Alcohols to Carbonyl Compounds with NHPI/CAN Catalytic System. Synthetic Communications, 33, 2237-2243. 

Attempts to achieve selective oxidations of hydrocarbons or other compounds when the desired site of attack is remote from an activating functional group are faced with several difficulties. With powerful transition-metal oxidants, the initial oxidation products are almost always more susceptible to oxidation than the starting material. When a hydrocarbon is oxidized, it is likely to be oxidized to a carboxylic acid, with chain cleavage by successive oxidation of alcohol and carbonyl intermediates. There are a few circumstances under which oxidations of hydrocarbons can be synthetically useful processes. One group involves catalytic industrial processes. Much effort has been expended on the development of selective catalytic oxidation processes and several have economic importance. We focus on several reactions that are used on a laboratory scale. 

Later, a nickel-catalyzed cascade conversion of propargyl halides and propargyl alcohol into a pyrone in water was reported. The reaction involved a carbonylation by CO and a cyanation by KCN (Eq. 4.55).96 Recently, Gabriele et al. explored a facile synthesis of maleic acids by palladium catalyzed-oxidative carbonylation of terminal alkynes in aqueous DME (1,2-dimethoxyethane) (Eq. 4.56).97... 

---