Diaryl sulfone

Polyarylether Ketones. The aromatic polyether ketones are tme thermoplastics. Although several are commercially available, two resins in particular, poly ether ether ketone [31694-16-3] (PEEK) from ICI and poly ether ketone ketone (PEKK) from Du Pont, have received most of the attention. PEEK was first synthesized in 1981 (20) and has been well studied it is the subject of numerous papers because of its potential use in high performance aircraft. Tough, semicrystalline PEEK is prepared by the condensation of bis(4-fiuorophenyl) ketone with the potassium salt of bis(4-hydroxyphenyl) ketone in a diaryl sulfone solvent, such as diphenyl sulfone. The choice of solvent is critical other solvents, such as Hquid HE, promote the reaction but lead to premature low molecular-weight crystals, which do not exhibit sufficient toughness (21). 

Tnfluoroacetic anhydnde in a mixture with sulfuric acid is an efficient reagent for the sulfonylation of aromatic compounds [44] The reaction of benzene with this system in nitromethane at room temperature gives diphenyl sulfone in 61% yield Alkyl and alkoxy benzenes under similar conditions form the corresponding diaryl sulfones in almost quantitative yield, whereas yields of sulfones from deactivated arenes such as chlorobenzene are substantially lower [44] The same reagent (tnfluoroacetic anhydride-sulfunc acid) reacts with adamantane and its derivatives with formation of isomeric adamantanols, adamantanones, and cyclic sultones [45]... 

Kevan and colleagues69 studied the products of the radiolysis of solid diaryl sulfones at room temperature, such as p,p -ditolyl, diphenyl sulfone and dibenzothiophene-S,S-dioxide. The products found for the first two were S02 and the diaryl hydrocarbon. For p,p -ditolyl sulfone the S02 yield is linear with dose upto about 13 Mrad, above which it falls off considerably from linearity. The initial yields give G(S02) = 0.05, which is equal within experimental error to the yield of p,p -bitolyl. The only another organic product observed had a smaller yield by a factor of 7, and could not be identified. The authors pointed out that no polymeric product was found in contrast to what is known on benzene radiolysis. The mass balance suggests that a simple decomposition as shown by equation 50 is the net consequence of radiolysis. 

In dibenzothiophene-S,S-dioxide the S atom is in a ring, and hence more constrained. The yield of SOz in the radiolysis is linear with the dose to about 13 Mrad after which it levels off as in p,p -ditolyI sulfone. However, the yield of S02 in this case is much lower (a factor of 25) than in the case of p,p -ditolyl sulfone (G = 0.002 compared to G = 0.05). This stability of the dibenzothiophene sulfone could be partially due to back reaction to reform the parent sulfone and partially due to more efficient energy delocalization. The expected biphenylene product was not detected due to limitations of the analytical method. Bowmer and O Donnell70 studied the volatile products in y-radiolysis of dialkyl, alkyl aryl and diaryl sulfones. Table 2 gives the radiolytic yields of S02 and of the hydrocarbon products of the alkyl or aryl radicals. The hydrocarbon products are those obtained either by H atom abstraction or by radical combination. The authors69 suggested the mechanism... 

Diaryl sulfones can be formed by treatment of aromatic compounds with aryl sulfonyl chlorides and a Friedel-Crafts catalyst. This reaction is analogous to Friedel-Crafts acylation with carboxylic acid halides (11-14). In a better procedure, the aromatic compound is treated with an aryl sulfonic acid and P2O5 in polypho-sphoric acid. Still another method uses an arylsulfonic trifluoromethanesulfonic anhydride (ArS020S02CF3) (generated in situ from ArS02Br and CF3S03Ag) without a catalyst. ... 

Since the classical paper of Meyerson and coworkers in 1964 on the electron impact(EI) mass spectra of diaryl sulfones, only some more than one hundred original reports dealing with the mass spectra of sulfoxides and sulfones have been published. These data have been reviewed quite extensively, most recently by Khmel nitskii and Efremov in a review on The rearrangements in sulfoxides and sulfones induced by electron impact and by Porter. Several less comprehensive surveys have also been presented " . Since Reference 2 and to a lesser extent Reference 4 cover the El mass spectra of alkyl and aryl sulfoxides and sulfones up to 1974 fairly completely, and Reference 3 together with Reference 2 the mass spectra of heterocyclic sulfoxides and sulfones and their nitrogen-containing counterparts up to 1980, the present chapter will mainly concentrate on the most recent developments and some complementary material not described in the above-mentioned reviews. 

Directed lithiation of aromatic compounds is a reaction of broad scope and considerable synthetic utility. The metalation of arenesulfonyl systems was first observed by Gilman and Webb and by Truce and Amos who reported that diphenyl sulfone is easily metalated at an orf/io-position by butyllithium. Subsequently, in 1958, Truce and coworkers discovered that metalation of mesityl phenyl sulfone (110) occurred entirely at an orf/io-methyl group and not at a ring carbon, as expected. Furthermore, refluxing an ether solution of the lithiated species resulted in a novel and unusual variation of the Smiles rearrangement and formation of 2-benzyl-4,6-dimethyl-benzenesulfinic acid (111) in almost quatitative yield (equation 78). Several other o-methyl diaryl sulfones have also been shown to rearrange to o-benzylbenzenesulfinic acids when heated in ether solution with... 

Several studies have been performed on the photodecomposition of diaryl sulfones and polysulfones Khodair, et. al., (21) demonstrated that the photodecomposition of diaryl sulfones proceeds by a free-radical mechanism with initial carbon-sulfur bond cleavage. This gives an aryl radical and an aromatic sulfonyl radical. The latter radical can react with oxygen and a hydrogen donor to eventually form the hydroxyl radical. The hydroxy radical may attack the aromatic nucleus in PET and forms the hydroxyterephthaloyl radical. 

The substrates exhibited enhanced reactivity, giving almost complete yields of diaryl sulfones under ambient conditions. Studies concerning the effect of Lewis acidity of the ionic liquid on the initial extent of conversion of this reaction have been completed using Al-NMR spectroscopy as a tool to investigate the mechanistic details of the reaction. Al-NMR spectral studies... 

Diary,I sulfones. Sulfuric acid and trifluoroacetic anhydride (1 2 equivalents) form bis(trifluoroacetyl) sulfate (1). which converts arenes and phenol ethers into diaryl sulfones in 70-99% yield. 

Interestingly, exclusive ipso substitution was observed in the reaction of trialkylarylstannanes with arenesulfonyl chlorides [118]. Diaryl sulfones, with substitution patterns different from those available via electrophilic aromatic substitution, were obtained in good to excellent yields. The... 

---