Tri-«-butyl phosphate

Solvating extractants contain one or more electron donor atoms, usually oxygen, which can supplant or partially supplant the water which is attached to the metal ions. Perhaps the best known example of such an extractant is tri-( -butyl) phosphate) [126-73-8] (TBP), which forms... 

As metal extraction into a diluent—extractant solution proceeds, there is sometimes a tendency for formation of two organic phases in equiHbrium with the aqueous phase. A third phase is highly undesirable and its formation can be prevented by adding to the organic phase a few percent of a modifier which is typically a higher alcohol or tri- -butyl phosphate (TBP) (7). 

Chemistry. Chemical separation is achieved by countercurrent Hquid— Hquid extraction and involves the mass transfer of solutes between an aqueous phase and an immiscible organic phase. In the PUREX process, the organic phase is typically a mixture of 30% by volume tri- -butyl phosphate (solvent) and a normal paraffin hydrocarbon (diluent). The latter is typically dodecane or a high grade kerosene (20). A number of other solvent or diluent systems have been investigated, but none has proved to be a substantial improvement (21). 

The solubility of the actinides in the organic phase, the right-hand side of equation 3, is achieved by the weak complexes that tri- -butyl phosphate... 

Many organic reagents have been used successfully in Pu separation processes. The reagents include tri- -butyl phosphate (TBP) methyl isobutyl ketone thenoyl ttifluoroacetone (TTA) ethers, eg, diethyl ether, di- -butyl ether, tetraethylene glycol dibutyl ether trdaurylamine (TT,A) trioctylamine (TOA) di- -butyl phosphate (DBP) hexyl-di(2-ethylhexyl) phosphate (HDEHP) and many others. Of these, TBP is by far the most widely used (30,95). 

Intermediate-duration oral exposure to Durad 110 produced deaths in chickens associated with the delayed development of neuropathy at dosage levels of 4,000 mg/kg/day in a 28-day study and 90 mg/kg/day in a 90-day study (FMC 1986). At 100 mg/kg/day over a 13-week period, 2 of 12 male and 1 of 12 female rats died with exposure to tri- -butyl phosphate (Healy et al. 1995). Dietary administration of Pydraul 90E for 90 days providing daily doses of 50 mg/kg/day produced no chemical-related deaths in rats (Monsanto 1979). An organophosphate ester hydraulic fluid designated MIL-H-83306 also caused death in 4 of 4 rats exposed by gavage to 1,000 mg/kg over a 26-day period (Mattie et al. 1993). 

Alkyl esters of phosphoric acid and phosphine oxides will extract metals and mineral acids by direct solvation. Tri-//-butyl phosphate (TBP) and tri- -octyl phosphine oxide (TOPO)... 

Co2(S04)i Electrochemical oxidation of C0SO4 generated 02(804)3 that reacted with 1-naphthylmethanol in tri-butyl phosphate to give 1-naphthaldehyde in 66% yield [29, 30]. 

Prayon One of the Wet processes for making phosphoric acid by reacting phosphate rock with sulfuric acid. The byproduct is gypsum, calcium sulfate dihydrate. It uses a compartmentalized, multi-section, lined, concrete reactor, with finishing tanks in which the gypsum crystals mature. In 1990 one third of the wet process phosphoric acid made in the Western World was made in this way. The process was developed in 1977 by the Societe de Prayon, Belgium. Variations are known as PH2, PHI 1, and PH12. One variation nses solvent extraction with isopropyl ether and tri- -butyl phosphate. 

Latham L, Long G, Broxup B Induction of urinary bladder hyperplasia in Sprague-Dawley rats orally administered tri- -butyl phosphate. Arch Environ Health 40 310-306, 1985... 

In sub-FC, a detailed study of the influence of mobile phase additives on the chiral resolution of isoxazoline-based Ilb/IIIb receptor antagonists was carried out by Blackwell [145] on Chiralcel OD-H CSPs. The different mobile phase additives used were acetic acid, trifluoroacetic acid, formic acid, water, triethylamine, triethanolamine, n-hexylamine, trimethyl phosphate, and tri-w-butyl phosphate. In general, n-hexylamine and tri-/ -butyl phosphate mobile phase additives resulted in better resolution. The chiral separation of four 1,3-dioxolane derivatives on an amylose-based column has been described [151]. The effects of mobile phase composition, temperature, and pressure have been investigated. The nature of the modifier is the main parameter it has the highest impact on chiral resolution and is more important than the polarity of the mobile phase. Therefore, the organic modifier that gave the best enantiomeric separation was different for each compound. 

Taylor, R.J., Sinkov, S.I., Choppin, G.R., May, I. 2008. Solvent extraction behavior of neptunium(rV) ions between nitric acid and diluted 30 % tri-butyl phosphate in the presence of simple hydroxamic acids. Solvent Extr. Ion Exch. 26 (1) 41-61. 

Extraction by solvation involves the displacement of some or all of the water molecules in the coordination sphere of a metal complex by neutral organic donors, conferring high solubility in water-immiscible solvents. Solvating extractants are typically ethers, ketones, or neutral phosphorus(V) molecules containing P=0 units, e.g. the extraction of uranium(VI) from nitrate solutions by tri- -butyl phosphate (TBP). 

Purex [Plutonium and uranium recovery by extraction] A process for the solvent extraction of plutonium from solutions of uranium and fission products, obtained by dissolving spent nuclear fuel elements in nitric acid. The solvent is tri- -butyl phosphate (TBP) in kerosene. First operated by the U.S. Atomic Energy Commission at its Savannah River plant, SC, in 1954 and at Hanford, WA, in 1956. Now in operation, with modifications, in several countries. Sites include Savannah River (SC), Cap de la Hague (France), Marcoule (France), Sellafield (England), Karlsruhe (Germany), and Trombay (India). See also Recuplex. 

---