O- Nitrophenol

Students should carry out the purification by steam distillation of (a) crude nitrobenzene or chlorobenzene, or of (b) crude naphthalene, o-nitrophenol (p. 170) or />-tolunitrile (p. 194) as examples of solid compounds which may also be purified in this way. When the distillation is complete, disconnect the tubing (Fig. 15) between C and D before removing the flame from under D, otherwise the contents of C will be sucked back into D as the latter cools. 

For the latter purpose, dissolve the crystals in hot ethanol, and then add water drop by drop to the well-stirred solution until a line emulsion just appears then add more ethanol, also drop by drop, until the emulsion just redissolves. ow allow the solution to cool spontaneousK if the emulsion reappears, add a few drops of ethanol from time to time in order to keep the solution clear. Finally the o-nitrophenol separates in crystals, and the well-stirred mixture may now be cooled in ieewvater until crystallisation is complete. Filter, drain and diy either in an atmospheric desiccator, or by pressing between drying-paper. 

The o-nitrophenol is obtained as bright yellow crystals, m.p. 46°, possessing an odour which resembles both that of phenol and of nitrobenzene. 

Give acetyl derivatives, but that from o-nitrophenol is not so readily obtained. 

Reduction to aminophenol. Reduce about 0 5 g. of o-nitrophenol with cone. HCl and tin as described on p. 385. After a few minutes the yellow molten o-nitrophenol disappears completely, the solution becoming homogeneous and colourless due to the formation of 0-aminophenol (which is soluble in HCl). Cool and add 30% aqueous NaOH solution note that a white precipitate is first formed and then redissolvcs in an excess of NaOH, and that the solution does not develop an orange coloration, indicating that the nitro-group has been reduced. 

Ferric chloride coloration. Add FeCl, solution to a few crystals (or to an aqueous solution) of /> nitrophenol a violet-red coloration is produced. o-Nitrophenol does not give a coloration. 

Acetylation. Heat i g. of />-nitrophenol with 5 ml. of an acetic acid-acetic anhydride mixture under reflux for 15 minutes. Pour into water the solid acetate separates. Filter, wash with water and re-crystallise from ethanol m.p. 77 5°. This treatment usually leaves o-nitrophenol unchanged. The addition, however, of about 0 5 ml. of cone. H2SO4 to the acetylating mixture gives the o-derivative, m.p. 40°. 

Yellow. Quinones, m- and p-nitroaniline, o-nitrophenol, and many other nitrO"Compounds. [Note that some nitro-compounds often appear yellow (e.g. m-dinitrobenzene and 3, 5 -dinitro-benzoic acid), but are colourless when absolutely pure.] Iodoform. 

In practice superheated steam is generally employed for substances with a low vapour pressure (< 5-1 mm.) at 100°. Thus in the recovery of the products of nitration or aromatic compounds, the ortho derivative e.g., o-nitrophenol) can be removed by ordinary steam distillation the... 

Cautiously add 250 g. (136 ml.) of concentrated sulphuric acid in a thin stream and with stirring to 400 ml. of water contained in a 1 litre bolt-head or three-necked flask, and then dissolve 150 g. of sodium nitrate in the diluted acid. Cool in a bath of ice or iced water. Melt 94 g. of phenol with 20 ml. of water, and add this from a separatory funnel to the stirred mixture in the flask at such a rate that the temperature does not rise above 20°. Continue the stirring for a further 2 hours after all the phenol has been added. Pour oflF the mother liquid from the resinous mixture of nitro compounds. Melt the residue with 500 ml. of water, shake and allow the contents of the flask to settle. Pour oflF the wash liquor and repeat the washing at least two or three times to ensure the complete removal of any residual acid. Steam distil the mixture (Fig. II, 40, 1 or Fig. II, 41, 1) until no more o-nitrophenol passes over if the latter tends to solidify in the condenser, turn oflF the cooling water temporarily. Collect the distillate in cold water, filter at the pump, and drain thoroughly. Dry upon filter paper in the air. The yield of o-nitrophenol, m.p. 46° (1), is 50 g. 

The melting points of some 0-aryl saccharin derivatives are phenol, 182° o-cresol, 163° m-cresol, 146° p-cresol, 172° o-nitrophenol, 236° p-nitrophenol, 192°. 

Phenol. The change in the orientation of substitution into phenol as a result of the superimposition of nitrosation on nitration is a well-established phenomenon. In aqueous sulphuric acid it leads to a change from the production of 73 % of o-nitrophenol under nitrating... 

Expts. /-j. Yields of mono-nitrophenols were 70-80%. The yields of o-nitrophenol are subject to errors of several units %. KHSO4 was present in concentration equivalent to [HNO3] + [HN02]. 

Nitromersol/777-j5 , y (4) and mercurophen [52486-78-9] (5) are prepared by the same mercuration reaction as phenyhnercuric acetate, only 4-nitro-(9-cresol and o-nitrophenol are used, respectively, iastead of benzene. The second step is reaction with sodium hydroxide to form the anhydride or sodium salt, respectively. 

Ester, aldehyde, carbonate, phosphate, nitrate, nitrite, nitrile, intramolecular bonding, e.g., o-nitrophenol - 0 -1- - -1- -1- 0 -1- -1- 0 -1- -1-... 

The impurities present in aromatic nitro compounds depend on the aromatic portion of the molecule. Thus, benzene, phenols or anilines are probable impurities in nitrobenzene, nitrophenols and nitroanilines, respectively. Purification should be carried out accordingly. Isomeric compounds are likely to remain as impurities after the preliminary purifications to remove basic and acidic contaminants. For example, o-nitrophenol may be found in samples ofp-nitrophenol. Usually, the ri-nitro compounds are more steam volatile than the p-nitro isomers, and can be separated in this way. Polynitro impurities in mononitro compounds can be readily removed because of their relatively lower solubilities in solvents. With acidic or basic nitro compounds which cannot be separated in the above manner, advantage may be taken of their differences in pK values (see Chapter 1). The compounds can thus be purified by preliminary extractions with several sets of aqueous buffers... 

Chemical Designations - Synonyms 2-Hydroxynitrobenzene o-Nitrophenol ONP Chemical Formula 1,2-HOC H4NOj. 

Some ortho-substituted phenols, such as o-nitrophenol, have significantly lower-boiling points than those of the rneta and para isomers. This is because the intramolecular hydrogen bond that forms between the hydroxyl group and the substituent partially compensates for the energy required to go from the liquid state to the vapor. 

---