Isocyanates phenyl isocyanate

Cyanic acid esters Isocyanates Phenyl isocyanate... 

MP PDEG in the composition of the polyester resin has end hydroxyl and carboxyl groups capable of interacting with the isocyanate groups. To prevent the chemical interaction of the individual IPN networks, the MP PDEG end groups were pre-blocked with a monofunctional isocyanate (phenyl isocyanate) later this reaction was excluded with almost no effect upon the adhesive properties. 

MeNHj CO, Me NCONMe Cyanic acid esters, PhOCN, p-Tolyl cyanate, 2,4-Di-methylphenyl -Isocyanates Phenyl isocyanate 2-Ethoxy-N-ethoxy-carbonyl-1,2-dihydro-quinoline Carbodiimides Diisopropyl-carbo-diimide, Dicyclohexyl-, Di-p-tolyl-Polyhexamethylene-carbodiimide N-Methyl-N,N -dicyclo-hexylcarbodiimidium iodide... 

CH NHhCO, (CH,) CON(CHs) Cyanic acid esters, C HfiCN, 2,4-Di-methylphenyl cyanate Isocyanates Phenyl isocyanate... 

C0(NH2)2, (CHsNH)fiO, (CHs)2NC0N(CH,), Cyanic acid esters Isocyanates Phenyl isocyanate... 

D) Phenylurea Derivatives. This reaction usually proceeds readily when cold solutions of the dried amine and of phenyl isocyanate, each in petroleum (b.p. 100-120 ), are mixed if no reaction is obvious, heat under reflux for 30 minutes. Care in using the isocyanate, p. 336.)... 

Phenyl- and a-naphthyl-urethanes (Phenyl- and a-naphthyl-carbamates). Both phenyl isocyanate and a-naphthyl isocyanate react with alcohols to yield phenyl-urethanes and a-naphthyl-urethanes respectively ... 

Anilides and a-Naphthalides. The Grignard reagents prepared from alkyl halides react with phenyl isocyanate (CgHjN=C=0) or with a-uaphthy l isocyanate (C,oH, N=C=0) to yield addition products that are converted by hydrolysis into anihdes and a-naphthalides respectively RX + Mg —> RMgX... 

Phenyl isocyanate is a colourless liquid, b.p. 164° or 55°/13 mm. its vapour is lacluymatory. The liquid reacts readily with water, yielding diphenyl urea, m.p. 241°, and hence must be protected from atmospheric moisture ... 

The phenylhydantoic acid is prepared similarly, using phenyl isocyanate. The latter is more sensitive to water than a-naphthyl isocyanate and therefore does not keep so well. 

Alcohols (but not ethers) also react with phenyl isocyanate or with the corre-sponding crystalline a-naphttiyl isocyanate to give carbamates or urethanes (see Section 111,27, ), but these substances are hardly suitable as class reagents. 

The cyclic carbamate (oxazoIidin-2-one) 313 is formed by the reaction of phenyl isocyanate (312) with vinyloxirane[I92]. Nitrogen serves as a nucleophile and attacks the carbon vicinal to the oxygen exclusively. The thermodynamically less stable Z-isomer 315 was obtained as a major product (10 I) by the reaction of 2-methoxy-l-naphthyI isocyanate (314) with a vinyloxir-... 

Reductive carbonylation of nitro compounds is catalyzed by various Pd catalysts. Phenyl isocyanate (93) is produced by the PdCl2-catalyzed reductive carbonylation (deoxygenation) of nitrobenzene with CO, probably via nitrene formation. Extensive studies have been carried out to develop the phosgene-free commercial process for phenyl isocyanate production from nitroben-zene[76]. Effects of various additives such as phenanthroline have been stu-died[77-79]. The co-catalysts of montmorillonite-bipyridylpalladium acetate and Ru3(CO) 2 are used for the reductive carbonylation oLnitroarenes[80,81]. Extensive studies on the reaction in alcohol to form the A -phenylurethane 94 have also been carried out[82-87]. Reaction of nitrobenzene with CO in the presence of aniline affords diphenylurea (95)[88]. 

Double. silylation of the a-diketone 120 with (Me3Si)2 is catalyzed by PdCl2(Me3P)2 to give the l,2-bis(siloxy)ethylene 121 in a good yield[ll7], Hydro.silylation of phenyl isocyanate (122) catalyzed by PdCN affords the /V-... 

The nucleophilic reacbvity of the C-5 oxygen is well documented however, no quantitative data are available. A-2-Thiazoline-5-ones (212) react at oxygen with acetyl chloride or acetic anhydride (447. 452). benzoyl chloride (447). methyl or phenyl isocyanate (467). carbamoyl chloride (453, 467). or phosphorus derivatives (468, 428) in the presence of bases to give 213, 214, 215. or 216 (Scheme 109). Strong bases such as... 

Methylenebis(4-phenyl isocyanate). This compound is also known as methyl diisocyanate [101-68-8] (MDI) and is produced by the condensation of aniline and formaldehyde with subsequent phosgenation. Its principal end use is rigid urethane foams other end uses include elastic fibers and elastomers. Total formaldehyde use is 5% of production (115). 

Amides result from the reaction of aromatic hydrocarbons with isocyanates, such as phenyl isocyanate [103-71-9], ia the presence of aluminum chloride. Phenyl isothiocyanate [103-72-0] similarly gives thioanilides (136). 

Sodium methanenitronate reacts with phenyl isocyanate in benzene to give the readily separable sodium salts of nitroacetaniUde and nitromalondiarkhde. Except as the salt, nitromethane is unreactive with phenyl isocyanate at temperatures up to 100°C the higher homologues do not give condensation products that can be isolated. 

The hydroxyl number can be deterrnined in a number of ways such as acetylation, phthalation, reaction with phenyl isocyanate, and ir and nmr methods. An imidazole-catalyzed phthalation has been used to measure the hydroxyl number for a number of commercial polyether polyols and compared (favorably) to ASTM D2849 (uncatalyzed phthalation) (99). The uncatalyzed method requires two hours at 98°C compared to 15 minutes at the same temperature. 

Liquid Ghromatography/Mass Spectrometry. Increased use of Hquid chromatography/mass spectrometry (Ic/ms) for stmctural identification and trace analysis has become apparent. Thermospray Ic/ms has been used to identify by-products in phenyl isocyanate precolumn derivatization reactions (74). Five compounds resulting from the reaction of phenyUsocyanate and the reaction medium were identified two from a reaction between phenyl isocyanate and methanol, two from the reaction between phenyl isocyanate and water, and one from the polymerisation of phenyl isocyanate. There were also two reports of derivatisation to enhance either the response or stmctural information from thermospray Ic/ms for linoleic acid hpoxygenase metabohtes (75) and for cortisol (76). 

---