Rhodium-Catalyzed Asymmetric Hydroformylation of Styrene

The potential of QUINAPHOS ligands for asymmetric catalysis was assessed in rhodium-catalyzed enantioselective hydroformylation using styrene as a benchmark substrate (Table 2.1.5.2). The catalysts were prepared in situ from [(acac)Rh(CO)2] and 4 equiv of the diastereomeric mixture or the single diaste- 

---

Fig. 6 Rhodium-catalyzed asymmetric hydroformylation of styrene using ligands 3 and 23-26. Enantioselectivities obtained at 100 bars of syngas and 60 °C are shown in brackets...

I 7 Enantioselective Catalysis in Ionic Liquids and Supercritical CO Table 7.17 Rhodium-catalyzed asymmetric hydroformylation of styrene in SCCO2. 

Figure4 Experimental setup for polystyrene-supported (R,S)-BINAPHOS-rhodium-catalyzed asymmetric hydroformylation of styrene (adapted from [18]).

The chiral diphosphites 4-9 have been used in the rhodium catalyzed asymmetric hydroformylation of styrene. The catalysts are prepared in situ by adding the diphosphite L to [Rh(acac)(CO)2] (acac = acetylacetonate) as a catalyst precursor. Under typical hydroformylation conditions the active catalyst precursor [RhH(diphosphite)(CO)2] is formed (See 5.2.3). Two important features have been found for the preparation of efficient catalyst using these diphosphites (1) An excess of diphosphite is used to exclude the... 

In a recent study, Kainz and Leitner (187) demonstrated the use of the chiral phosphine/phosphite ligand (/ ,5)-BINAPHOS for the rhodium-catalyzed asymmetrical hydroformylation of styrene according to Scheme 18. They report that the reaction proceeds cleanly and almost quantitatively in SCCO2 at 60°C and gives appreciable enantiomeric excess [ee = 66% (/ )] at densities close... 

Chiral diphosphites based on (2R,3R)-butane-2,3-diol, (2R,4R)-pentane-2,4-diol, (25, 5S)-hexane-2,5-diol, (lS -diphenylpropane-hS-diol, and tV-benzyltartarimide as chiral bridges have been used in the Rh-catalyzed asymmetric hydroformylation of styrene. Enantioselectivities up to 76%, at 50% conversion, have been obtained with stable hydridorhodium diphosphite catalysts. The solution structures of [RhH(L)(CO)2] complexes have been studied NMR and IR spectroscopic data revealed fluxional behavior. Depending on the structure of the bridge, the diphosphite adopts equatorial-equatorial or equatorial-axial coordination to the rhodium. The structure and the stability of the catalysts play a role in the asymmetric induction.218... 

Chiral thioureas have been synthesized and used as ligands for the asymmetric hydroformylation of styrene catalyzed by rhodium(I) complexes. The best results were obtained with /V-phenyl-TV -OS )-(l-phenylethyl)thiourea associated with a cationic rhodium(I) precursor, and asymmetric induction of 40% was then achieved.387,388 Chiral polyether-phosphite ligands derived from (5)-binaphthol were prepared and combined with [Rh(cod)2]BF4. These systems showed high activity, chemo- and regio-selectivity for the catalytic enantioselective hydroformylation of styrene in thermoregulated phase-transfer conditions. Ee values of up to 25% were obtained and recycling was possible without loss of enantioselectivity.389... 

A polymer-supported rhodium catalyst modified with Diop attached to non-cross-linked polystyrene, first used in the asymmetric hydroformylation of styrene, gives 95 % branched aldehyde, however with only 2% ee9. Further developments in the preparation and use of cross-linked polymers with attached chiral phosphane ligands (Diop, DIPHOL, BPPM) in rhodium- and platinum-catalyzed asymmetric hydroformylation have led to good to excellent results with respect to the asymmetric induction62-124 157,159 and arc described in Section 1.5.8 2.2.3.2. The results arc integrated in Table 4. 

In spite of extensive studies on the asymmetric hydroformylation of olefins using chiral rhodium and platinum complexes as catalysts in early days, enantioselectivity had not exceeded 60% ee until the reaction of styrene catalyzed by PtCl2[DBP-DIOP (l)]/SnCl-> was reported to attain 95% ee in 1982 [8]. Although the value was corrected to 73% ee in 1983 [9], this result spurred further studies of the reaction in connection to possible commercial synthesis of antiinflammatory drugs such as (S)-ibuprofen and (S)-naproxen. The catalyst PtCl2[BPPM... 

Rhodium-Catalyzed Hydroformylation of Styrene with Different Asymmetric Ligands... 

The soluble polymer-supported catalysts have also been used for asymmetrically catalyzed reactions Following a procedure for the preparation of insoluble polymeric chiral catalysts a soluble linear polystyrene-supported chiral rhodium catalyst has been prepared. This catalyst displays high enantiomeric selectivity compared to the low molecular weight catalyst. Thus, hydroformylation of styrene using this catalyst produces aldehydes in high yields. The branched chiral hy drotropaldehy de is formed in 95% selectivity. 

Platinum complexes with chiral phosphorus ligands have been extensively used in asymmetric hydroformylation. In most cases, styrene has been used as the substrate to evaluate the efficiency of the catalyst systems. In addition, styrere was of interest as a model intermediate in the synthesis of arylpropionic acids, a family of anti-inflammatory drugs.308,309 Until 1993 the best enantio-selectivities in asymmetric hydroformylation were provided by platinum complexes, although the activities and regioselectivities were, in many cases, far from the obtained for rhodium catalysts. A report on asymmetric carbonylation was published in 1993.310 Two reviews dedicated to asymmetric hydroformylation, which appeared in 1995, include the most important studies and results on platinum-catalogued asymmetric hydroformylation.80,81 A report appeared in 1999 about hydrocarbonylation of carbon-carbon double bonds catalyzed by Ptn complexes, including a proposal for a mechanism for this process.311... 

---